[0001] The present invention relates to dishwashing machines, and in particular to a dishwasher
in which various sensors are gathered in a sensor group located in the washing tank.
[0002] It is known that dishwashers are more and more provided with different types of sensors
to allow them to carry out "automatic" washing cycles, i.e. washing cycles selected
by the control unit of the machine among the various combinations available according
to the actual working conditions of the machine, reducing to a minimum the setting
by the user. The sensors are used to detect at each cycle various parameters such
as type and amount of dirt, entering water hardness, etc. which are the information
required to consequently adapt the various working parameters (temperature, amount
of water, number of water loads, cycle duration, etc.).
[0003] All of this is done with the purpose of optimizing the consumption of power, water
and salt on the basis of the actual needs yet assuring good washing and drying results.
In practice, the sensors allow the selection among the various washing solutions to
adapt the latter to the number and type of dishes to be washed, for example by setting
low temperature cycles, or power recovery cycles, or by feeding one sprinkler only
and so on.
[0004] The commonly used sensors, in order to operate properly, in general must be immersed
in the washing liquid and the liquid itself must be (at the time of the "reading")
almost at rest. As a consequence, the sensors are arranged in areas of the hydraulic
circuit where the flow is not turbulent or, if they are directly located inside the
washing liquid passage ducts, at the time of the reading it is necessary to slow down
or stop for some seconds the washing pump.
[0005] However these known solutions have drawbacks, since in the case of sensors arranged
in quiet areas there can be dirt deposit phenomena which affect their operation, while
if they are located in the passage ducts the slowing down or stopping of the pump
can result in a more complex management of the cycle and/or a more complex manufacturing
of the pump which requires a rotational speed control.
[0006] Moreover in both cases the sensors can not be inspected, whereby it can not be excluded
that a soiling takes place over time which eventually causes the detection of wrong
data, of which the user may hardly be aware and to which in any case he could not
directly see himself.
[0007] Finally a further drawback stems from the fact that the sensors are arranged in various
areas of the machine, which results in a complicated assembly and maintenance due
to the wiring and connections required.
[0008] Therefore the object of the present invention is to provide a dishwasher which overcomes
the above-mentioned drawbacks.
[0009] This object is achieved by means of a dishwasher in which the various sensors are
gathered in a sensor group located in the washing tank. Other advantageous features
are disclosed in the dependent claims.
[0010] A first advantage of the dishwasher according to the present invention is that of
concentrating the sensors in a single area of the machine, thus simplifying the construction
and reducing the costs.
[0011] A second significant advantage of this dishwasher is that of providing an automatic
cleaning of the outer surface of the sensors at each cycle, so as to guarantee their
efficiency over time.
[0012] A further advantage of this type of machine stems from the fact that the sensor group
can be easily inspected even by the user, who can check the condition of the surfaces
and possibly see to an additional manual cleaning.
[0013] Further advantages and characteristics of the dishwasher according to the present
invention will be clear to those skilled in the art from the following detailed description
of an embodiment thereof, with reference to the annexed drawings wherein:
Fig.1 is a diagrammatic top plan view which shows the essential elements of the sensor
group and their relevant connections;
Fig.2 is a lateral sectional view taken along line A-A of fig. 1;
Fig.3 is a front sectional view taken along line B-B of fig.2;
Fig.4 is a view similar to fig.2 of the sensor group in a parameter detection step;
Fig.5 is a diagrammatic partial side view which shows a possible location of the sensor
group, which is shown in the reading step of fig.4; and
Fig.6 is a view similar to the preceding one which shows the sensor group in the washing
step of fig.2.
[0014] With reference to figures 1 to 3, there is seen that the sensor group of the dishwasher
according to the invention conventionally includes a control unit U connected through
suitable wiring to a plurality of sensors, in the illustrated case two pairs of sensors
S, S'.
[0015] The novel aspect of the present dishwasher is given by the fact that said sensors
S, S' are housed in a body C provided with a top opening F and with a front mobile
wall M which can open or close a bottom opening D by rotating around horizontal pins
R.
[0016] More specifically, body C is provided with a gasket G on the three sides along which
the mobile wall M abuts, said wall being biased on body C by torsion springs T arranged
around pins R. The contact between the mobile wall M and gasket G is prevented by
a central pusher P whose position is defined by an electro actuator E which is in
turn controlled by the control unit U. In particular, pusher P is kept in the extracted
position of fig.2 by a spring having a strength greater than the torsion springs T
which tend to close the mobile wall M on body C.
[0017] In the light of the description above and with reference also to figures 4 to 6,
the simple operation of the present dishwasher is readily understood.
[0018] Body C is arranged on one of the four vertical walls of the washing tank, preferably
on the door a little higher than the upper sprinkler J as illustrated in figs.5 and
6, and the mobile wall M usually maintains a substantially vertical position due to
the extracted position of pusher P. In this way the water can freely pass through
the sensor group and also the end jet X of sprinkler J can wash the inside of body
C by entering through the bottom opening D (fig.6).
[0019] In order for sensors S, S' which must operate by immersion to be able to carry out
the reading, at the times in the cycle where provided, pusher P is retracted by electro
actuator E thus allowing the mobile wall M to abut on the three sides (bottom and
lateral sides) of gasket G by rotating on pins R under the push of springs T.
[0020] In this condition the water drops and the squirts rebounding from above in a little
time will fill with washing liquid W, as confirmed by experimental tests performed
by the applicant, the space which has been formed between wall M and body C (figs.4,
5). It should be noted that possible small leakages between wall M and gasket G are
not a problem in that at the same time the flow of liquid from above continues, and
the liquid contained in the space is therefore in a condition of sufficient quiet
for the readings.
[0021] After the set time has elapsed, electro actuator E releases pusher P and wall M is
pushed back to the vertical position, thus allowing the discharge of the washing liquid
W and facilitating the washing of sensors S, S' by the jets of sprinkler J.
[0022] Moreover, if the user wishes to inspect/clean the sensors it is possible to manually
rotate wall M through 180° upwards; springs T will then return it into abutment on
pusher P.
[0023] It is clear that the above-described and illustrated embodiment of the dishwasher
according to the invention is just an example susceptible of various modifications.
In particular, the number, type and arrangement of the sensors inside body C can be
somewhat changed, and body C itself can be arranged in other positions in the washing
tank as long as it receives a sufficient amount of water to wash the sensors and to
create a temporary stagnation area for the liquid in order to detect the required
parameters.
[0024] Furthermore, the opening and closing mechanism of the water collecting space can
be made in other ways, for example by reversing the above-illustrated mechanism. In
other words, the mobile wall M might be elastically biased away from body C and electro
actuator E could be activated to push wall M against body C.
[0025] In another case wall M could be a laterally sliding wall which, under the push of
the electro actuator overcoming the resistance of the spring biasing wall M open,
closes the sides and bottom of body C which is normally completely open. As an alternative,
the spring could be present on pusher P only which in turn keeps wall M open, and
the activation of electro actuator E could cause the closing of wall M through a bidirectional
restraint, e.g. a crank mechanism.
[0026] Finally, electro actuator E itself could be replaced by another type of actuator,
e.g. hydraulic or pneumatic, suitable to lock the pusher both in the extracted and
retracted position, so that there would be no need for springs neither on pusher P
nor on the mobile wall M.
1. A dishwasher including a control unit (U) and a plurality of sensors (S, S') operationally
connected thereto, characterized in that said sensors (S, S') are housed in a body (C) arranged on one of the four vertical
walls of the dishwasher washing tank, said body (C) being provided with a top opening
(F) and a mobile wall (M), the opening and closing movement of said mobile wall (M)
to form a washing liquid stagnation space being controlled by said control unit (U)
through an actuator which acts on the mobile wall (M) through a pusher (P).
2. A dishwasher according to claim 1, characterized in that said actuator is an electro actuator (E).
3. A dishwasher according to claim 1 or 2, characterized in that the mobile wall (M) is elastically biased against the body (C) by one or more springs.
4. A dishwasher according to one or more of the preceding claims, characterized in that the mobile wall (M) rotates around horizontal pins (R) to open and close a bottom
opening (D), the body (C) being provided with a gasket (G) on three sides along which
the mobile wall (M) abuts, the latter being biased on the body (C) by torsion springs
(T) arranged around said pins (R).
5. A dishwasher according to claim 4, characterized in that the mobile wall (M) can be manually rotated through 180° upwards.
6. A dishwasher according to one or more of the preceding claims, characterized in that the pusher (P) is located in a central position in the body (C) and is kept by a
spring in an extracted position with respect to the electro actuator (E) whereby the
mobile wall (M) remains at a distance from the body (C).
7. A dishwasher according to one or more of claims 1 to 3, characterized in that the mobile wall (M) is slidable with respect to the body (C) in such a way that during
the washing step the latter is completely open.
8. A dishwasher according to claim 8, characterized in that the push of the actuator overcomes the resistance of a spring biasing the mobile
wall (M) open.
9. A dishwasher according to one or more of the preceding claims, characterized in that the body (C) is arranged on the door a little higher than the upper sprinkler (J).